
一、产品简介 I Product Introduction FB-201 干净剂乃是针对细线路、小孔径之高密度配线板所开辟之硫酸型酸性干净剂,利用特别之界面活性剂,水洗性精良,具有精良之干净力,不打击电路板的防焊油墨及影像干膜,可强力去除铜面氧化,对铜线路外表具有干净及活化作用。 FB-201 cleaner is a acid cleaner designed for the high-density circuit with thin line and small hole, and it uses special interface activator, has good washing ability and cleaning ability; it will not attack the solder mask and image dry film of circuit board, can remove oxide on copper surface, and has cleaning and activation function on surface of copper line.
二、配槽办法 II Makeup Method
建浴尺度 : 1. Makeup Standard
1L槽液 1L solution |
次要作用 Main Function |
体积(ml) Volume |
纯水 Pure water |
溶剂 Solvent |
900ml |
FB-201 |
干净 Cleaning |
100ml |
操纵条件 : 2. Operating Condition
组份/参数 Component/Parameter |
最佳值/事情范畴/要求 Optimal value/Work Scope/Requirement |
浓 度 Concentration |
10% |
温 度 Temperature |
45 ℃ (40-50 ℃) |
时 间 Time |
5 分钟(4-6 分钟) 5 minutes (4-6 minutes) |
槽 材 质 Material of bath |
利用 PVC 或 P.P 材质之槽材质 Use PVC or PP as the bath material |
加 热 器 Heater |
石英 铁氟龙 Quartz, Teflon, |
过 滤 Filter |
10-20 μm PP滤心,3-4 turn-over/hr 10-20 μm PP filter element, 3-4 turn-over/hr |
搅 拌 Mixing |
过滤循环 Filter circulation |
水 洗 Water washing |
2 段水洗 Two sections of water washing |
槽液维护 : Maintenance of solution 1) 牢固添加: 1) Fixed adding 处置 1 m 2 需添加 FB-201 约 20 ml Add about 20ml FB-201 for processing 1 m 2; 2) 剖析校正: 2) Analysis and calibration 按照 “ 酸性干净剂 FB-201 剖析办法 “ 剖析校正 Make analysis and calibration according to “Analysis method of acid cleaner FB-201” 3) 换槽尺度: 3) Bath replacing standard 2 turn-over 换槽 2 turn-over: replace bath
三、产品性状 III Product Property
品名 Product name |
表面 Appearance |
比重 Specific gravity |
PH 值 PH Value |
闪火点 Flash point |
FB-201 |
无色通明液体 Colorless transparent liquid |
1.05±0.05 |
< 1 |
不行燃 Non- combustible |
四、留意事变 IV Notes 1、酸性干净剂 FB-201 是酸性腐化性液体,请制止身材间接打仗,请警惕利用。 1. Acid cleaner FB-201 is acid corrosive liquid, please avoid direct contact with body and use it carefully; 2、利用时请佩带手套、宁静眼镜,万一药液沾到眼睛时,请以净水冲洗 15 分锺以上,并至眼科诊所诊治。 2. When using it, Please wear gloves and eyeshade; in case of spattering into eye, immediately flush with clean water for over 15 minutes and get medical treatment; 3、产品贮存请安排阴凉处,并避免日晒,以避免产品蜕变。 3. The product shall be stored in cool place, being away from sunshine; |